Product ID:ACID DILUENT SOLUTION 01-ACIDDILUE
MSDS Date:03/30/1994
FSC:8030
NIIN:00N068937
MSDS Number: CBJSX

RANDOLPH PRODUCTS CO

701 12TH ST
CARLSTADT, NJ 07072-0830
US

Emergency Phone: 800-255-3924

Info Phone: 201-438-3700

Preparer: S.U.

Cage: 77672

RANDOLPH PRODUCTS CO

830 CARLSTADT, NJ 07072-0830 US

Telephone: 201-438-3700

Cage: 77672

0.3 @ 20C.

CAS: 7664-38-2

RTECS: TB6300000

Fraction By Weight: 20%

OSHA PEL 1 MG/M3

ACGIH TLV: 1 MG/M3;3 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

33 @ 20C.

CAS: 67-63-0

RTECS: NT8050000

Fraction By Weight: 70%

OSHA PEL 400 PPM

ACGIH TLV: 400 PPM;500 STEL

CLOTHING SHOULD BE WORN.

RTECS: 9999999ZZ

HAZARDOUS WASTE CODE F003 HAZARDOUS WASTE

RTECS: 9999999ZZ

TLV LIMIT. SOLVENT VAPORS SHOULD BE REMOVED FROM LOWER

RTECS: 9999999ZZ

& FULL LENGTH FACESHIELD .

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:CHRONIC HEALTH EFFECTS ARE POSSIBLE
FROM LONG TERM EXPOSURE TO THIS MATERIAL, INCLUDING DRYING,
CRACKING & IRRITATION OF SKIN. SKIN CONTACT CAUSES CHEMICAL BURNS.
REACTS W/SKIN PROTEIN & MOISTURE & CA N CAUSE RASH, SCALING OR
BLISTERING. HIGH CONCENTRATIONS MAY CAUSE HEADACHES & DIZZINESS,
ARE ANESTH, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:& MAY HAVE OTHER CENTRAL NERVOUS
SYSTEM EFFECTS, INCLUDING DEATH.
Medical Cond Aggravated by Exposure:PRE-EXISTING SENSITIVITY TO SOLVENT
CAN CAUSE A HEIGHTENED REACTION TO EXPOSURE TO THIS PRODUCT.

First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO FRESH AIR,
RESTORE BREATHING. CONSULT MD. SKIN:FLUSH W/WATER. EYES:FLUSH
IMMEDIATELY W/LARGE AMOUNTS OF WATER. CONSULT MD.

Flash Point Method:SCC
Flash Point:53.0F,11.7C
Lower Limits:2%
Upper Limits:12%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER STREAM WILL SPREAD FIRE. DO NOT USE WATER HOSE
STREAM.
Unusual Fire/Explosion Hazard:FLAMM LIQ - CLASS IB. KEEP CNTNRS TIGHTLY
CLSD. ISOLATE FROM HEAT, SPKS & OPEN FLAME. CLSD CNTNRS MAY EXPLODE
WHEN EXPOS TO EXTREME HEAT. WATER MAY BE (SUPDAT)

Spill Release Procedures:AVOID BRTHG SOLV VAP. ENSURE ADEQ VENT. AVOID
SPKS, FLAMES & ANYTHING WHICH COULD CAUSE FIRE. ELIM SOURCE OF
SPILL IF YOU CAN DO SO W/OUT RISK BY CLOSING VALVE, PLUGGING HOLE,
ETC. APPLY ABSORB INERT MATL (SAND, DUST, VERMICULITE) TO SPILL.
(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:DRUMS SHOULD BE GROUNDED WHEN BEING
EMPTIED.
Other Precautions:CONTACT LENS WEARERS SHOULD CONSULT PROVIDER BEFORE
HANDLING - CONSULT MD IMMEDIATELY IF THERE IS EYE CONTACT. PROVIDE
NIOSH/MSHA APPROVED RESPIRATORY PROTECTION AGAINST FUMES GENERATED
DURING BURNING .

Respiratory Protection:NIOSH/MSHA APPRVD RESP TYPES SUITABLE FOR INGS
REC. NIOSH/MSHA APPRVD CHEM/MECH FILTERS REC WHEN VENT IS
RESTRICTED. PRECS MUST BE TAKEN SO THAT PERS DO NOT BREATHE
VAPS/HAVE CONT W/EYES/SKIN. PROT AG AINST EXPOS TO BOTH VAP & SPRAY
MISTS.
Ventilation:SUFFICIENT VENT, IN VOL & PATTERN, SHOULD BE PROVIDED TO
KEEP AIR CONTAM BELOW CURRENT APPLIC OSHA PEL/ACGIH'S (ING 5)
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS (ING 6)
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . USE PROT CREAMS WHERE SKIN CONTACT IS
LIKELY.
Work Hygienic Practices:USE NORMAL HYGIENE PRACTICES DURING & AFTER
HANDLING THIS MATL. REMOVE & WASH CONTAM CLTHG BEFORE REUSE.
Supplemental Safety and Health
EXPLO HAZ:USED TO COOL CLSD CNTNRS TO PVNT PRESS BUILD-UP & POSS
AUTOIGNIT/EXPLO WHEN EXPOS TO EXTREME HEAT. REMOVE ALL NON-ESSNTL
PERS FROM FIRE AREA. VAP IS HVR/AIR & CAN TRAVEL CONSIDERABLE DISTS
T O SOURCE OF IGNIT & FLASHBACK. SPILL PROC:CLEAN SPILL W/BRISTLE
BROOMS, NON-SPARKING TOOLS, CLEAN DRY RAGS, PROT (ING 3)

Boiling Pt:B.P. Text:>130F,>54C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:0.91
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:THIN CLEAR LIQUID; TYPICAL SOLVENT ODOR.
Percent Volatiles by Volume:92.5

Stability Indicator/Materials to Avoid:YES
AVOID STRONG OXIDIZERS, ACIDS & ALKALIES.
Stability Condition to Avoid:THIS PRODUCT IS STABLE UNDER NORMAL
STORAGE CONDITIONS.
Hazardous Decomposition Products:THERMAL DECOMPOSITION RELEASES CARBON
MONOXIDE &/OR CARBON DIOXIDE.

Waste Disposal Methods:SOAK LIQS W/SAWDUST/RAGS & REMOVE. FLUSH W/WATER
IF POSS. AVOID SKIN CONT. DISP SHOULD BE I/A/W LOC, STATE & FED
REGS. DO NOT INCIN, CUT/WELD EMPTY CNTNRS. WHEN DISCARDED THIS MATL
IS HAZ WASTE. TRANS FER LIQ TO CNTNRS FOR RECOVERY/DISP. EPA (ING
4)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.